Wastewater treatment technologies opened the door for recovery of extracellular polymeric substances (EPS), presenting novel opportunities for use across diverse industrial sectors. Earlier studies showed that a significant amount of phosphorus (P) is recovered within extracted EPS. P recovered within the extracted EPS is an intrinsic part of the recovered material that potentially influences its properties. Understanding the P speciation in extracted EPS lays the foundation for leveraging the incorporated P in EPS to manipulate its properties and industrial applications. This study evaluated P speciation in EPS extracted from aerobic granular sludge (AGS). A fractionation lab protocol was established to consistently distinguish P species in extracted EPS liquid phase and polymer chains. ³¹P nuclear magnetic resonance (NMR) spectroscopy was used as a complementary technique to provide additional information on P speciation and track changes in P species during the EPS extraction process. Findings showed the dominance of organic phosphorus and orthophosphates within EPS, besides other minor fractions. On average, 25% orthophosphates in the polymer liquid phase, 52% organic phosphorus (equal ratio of mono and diesters) covalently bound to the polymer chains, 16% non-apatite inorganic phosphorus (NAIP) precipitates mainly FeP and AlP, and 7% pyrophosphates (6% in the liquid phase and 1% attached to the polymer chains) were identified. Polyphosphates were detected in initial AGS but hydrolyzed to orthophosphates, pyrophosphates, and possibly organic P (forming new esters) during the EPS extraction process. The knowledge created in this study is a step towards the goal of EPS engineering, manipulating P chemistry along the extraction process and enriching certain P species in EPS based on target properties and industrial applications.

@en

Kaumera are extracellular polymeric substances (EPS) extracted from excess aerobic granular sludge from Nereda® wastewater treatment plants. Kaumera exhibits significant market potential across diverse applications, fostering rapid research and business development. Furthermore, it will begin to be extracted from numerous installations worldwide. This calls for standard methods as analogue to (waste)water and sludge characterization. Due to lack of standardization, stakeholders are currently using different extraction and characterization protocols, impeding the development of a more uniform product and comparison of results across research studies. To address this, this report compiles the standard protocol for Kaumera extraction in the laboratory and for on-site and lab characterization to be used by researchers, the public Dutch water authorities, and the private industry. The procedures detailed in this document are in accordance with EPS research conducted at TU Delft and methodologies employed in Kaumera production facilities. This report aids in monitoring Kaumera characteristics worldwide and for optimizing the extraction process (including up and downstream processing). This will help maximize repeatability, interoperability, and quality and therefore accelerate business and research development, paving the way to develop a product that meets the needs of the endusers. Through the widespread adoption of this manual, our aim is to foster greater coordination and collaboration among stakeholders, thereby expediting the realization of Kaumera's full potential. @en

The study evaluated the combined phosphorus, nitrogen, methane, and extracellular polymeric substances (EPS) recovery from aerobic granular sludge (AGS) wastewater treatment plants. About 30% of sludge organics are recovered as EPS and 25–30% as methane (≈260 ml methane/g VS) by integrating alkaline anaerobic digestion (AD). It was shown that 20% of excess sludge total phosphorus (TP) ends in the EPS. Further, 20–30% ends in an acidic liquid waste stream (≈600 mg PO₄-P/L), and 15% in the AD centrate (≈800 mg PO₄-P/L) as ortho-phosphates in both streams and is recoverable via chemical precipitation. 30% of sludge total nitrogen (TN) is recovered as organic nitrogen in the EPS. Ammonium recovery from the alkaline high-temperature liquid stream is attractive, but it is not feasible for existing large-scale technologies because of low ammonium concentration. However, ammonium concentration in the AD centrate was calculated to be 2600 mg NH₄-N/L _– and ≈20% of TN, making it feasible for recovery. The methodology used in this study consisted of three main steps. The first step was to develop a laboratory protocol mimicking demonstration-scale EPS extraction conditions. The second step was to establish mass balances over the EPS extraction process on laboratory and demonstration scales within a full-scale AGS WWTP. Finally, the feasibility of resource recovery was evaluated based on concentrations, loads, and integration of existing technologies for resource recovery.

@en

Nereda® aerobic granular sludge plants will be urban biorefineries in near future. The development of Kaumera Nereda® Gum extractions from granular sludge was the first step. Kaumera is a biopolymer that can substitute oil derived polymers. Here we share our experiences in the EU funded Water Mining project. A transportable Kaumera extraction installation is build, additional technologies will be integrated: (I) nitrogen recovery, (II) phosphorus recovery and (III) alkaline fermentation of organic sludge residuals.
Together with industrial and public partners we combine fundamental research (alkaline fermentation and phosphorus recovery) with classical engineering (Kaumera Nereda® Gum extraction and nitrogen stripping) and process design. This technological process is supplemented with modern approaches from social, political, economic and environmental sciences to stimulate the commercialisation of these technologies and their concomitant recovery products. @en