While traveling through different zones in large-scale bioreactors, microbes are most likely subjected to fluctuating dissolved oxygen (DO) conditions at the timescales of global circulation time. In this study, to mimic industrial-scale spatial DO gradients, we present a scale-down setup based on dynamic feast/famine regime (150 s) that leads to repetitive cycles with rapid changes in DO availability in glucose-limited chemostat cultures of Penicillium chrysogenum. Such DO feast/famine regime induced a stable and repetitive pattern with a reproducible metabolic response in time, and the dynamic response of intracellular metabolites featured specific differences in terms of both coverage and magnitude in comparison to other dynamic conditions, for example, substrate feast/famine cycles. Remarkably, intracellular sugar polyols were considerably increased as the hallmark metabolites along with a dynamic and higher redox state nicotinamide adenine dinucleotide hydrogen/nicotinamide adenine dinucleotide of the cytosol. Despite the increased availability of NADPH for penicillin production under the oscillatory DO conditions, this positive effect may be counteracted by the decreased adenosine triphosphate supply. Moreover, it is interesting to note that not only the penicillin productivity was reduced under such oscillating DO conditions, but also that of the unrecyclable byproduct ortho-hydroxyphenyl acetic acid and degeneration of penicillin productivity. Furthermore, dynamic flux profiles showed the most pronounced variations in central carbon metabolism, amino acid (AA) metabolism, energy metabolism and fatty acid metabolism upon the DO oscillation. Taken together, the metabolic responses of P. chrysogenum to DO gradients reported here are important for elucidating metabolic regulation mechanisms, improving bioreactor design and scale-up procedures as well as for constructing robust cell strains to cope with heterogenous industrial culture conditions.@en

As the youngest of the quartet of systems biology tools alongside genomics, transcriptomics, and proteomics, metabolomics provides an immediate and dynamic recording of cells in response to genetic and/or environmental perturbations. Metabolomics study accelerates learning steps within the iterative design, build, test, and learn (DBTL) cycle for enhancing bioproduction capability. The associations between biological networks and environmental factors facilitate predictive modeling of cellular response, which is the basis for industrial application. This chapter presents an update on the metabolomics-driven biosystems engineering and bioprocess design principle from the metabolic perspective of organisms. Along with the introduction of the isotope dilution mass spectrometry (ID-MS) method to the fast sampling, quenching, and extraction protocol for quantitative metabolomics, metabolomics-assisted engineering biology and the establishment of metabolically structured models are highlighted. Furthermore, a computational framework based on a coupled metabolic-hydrodynamic approach is advocated to assess the interlocking architectures between environmental and biological networks in large-scale bioprocesses and provide suggestions toward bioreactor evaluation, scale-down, and optimization.@en

In industrial large-scale bioreactors, microorganisms encounter heterogeneous substrate concentration conditions, which can impact growth or product formation. Here we carried out an extended (12 h) experiment of repeated glucose pulsing with a 10-min period to simulate fluctuating glucose concentrations with Aspergillus niger producing glucoamylase, and investigated its dynamic response by rapid sampling and quantitative metabolomics. The 10-min period represents worst-case conditions, as in industrial bioreactors the average cycling duration is usually in the order of 1 min. We found that cell growth and the glucoamylase productivity were not significantly affected, despite striking metabolomic dynamics. Periodical dynamic responses were found across all central carbon metabolism pathways, with different time scales, and the frequently reported ATP paradox was confirmed for this A. niger strain under the dynamic conditions. A thermodynamics analysis revealed that several reactions of the central carbon metabolism remained in equilibrium even under periodical dynamic conditions. The dynamic response profiles of the intracellular metabolites did not change during the pulse exposure, showing no significant adaptation of the strain to the more than 60 perturbation cycles applied. The apparent high tolerance of the glucoamylase producing A. niger strain for extreme variations in the glucose availability presents valuable information for the design of robust industrial microbial hosts.

@en

Bioprocess scale-up is a critical step in process development. However, loss of production performance upon scaling-up, including reduced titer, yield, or productivity, has often been observed, hindering the commercialization of biotech innovations. Recent developments in scale-down studies assisted by computational fluid dynamics (CFD) and powerful stimulus–response metabolic models afford better process prediction and evaluation, enabling faster scale-up with minimal losses. In the future, an ideal bioprocess design would be guided by an in silico model that integrates cellular physiology (spatiotemporal multiscale cellular models) and fluid dynamics (CFD models). Nonetheless, there are challenges associated with both establishing predictive metabolic models and CFD coupling. By highlighting these and providing possible solutions here, we aim to advance the development of a computational framework to accelerate bioprocess scale-up.

@en

Metabolomics aims to address what and how regulatory mechanisms are coordinated to achieve flux optimality, different metabolic objectives as well as appropriate adaptations to dynamic nutrient availability. Recent decades have witnessed that the integration of metabolomics and fluxomics within the goal of synthetic biology has arrived at generating the desired bioproducts with improved bioconversion efficiency. Absolute metabolite quantification by isotope dilution mass spectrometry represents a functional readout of cellular biochemistry and contributes to the establishment of metabolic (structured) models required in systems metabolic engineering. In industrial practices, population heterogeneity arising from fluctuating nutrient availability frequently leads to performance losses, that is reduced commercial metrics (titer, rate, and yield). Hence, the development of more stable producers and more predictable bioprocesses can benefit from a quantitative understanding of spatial and temporal cell-to-cell heterogeneity within industrial bioprocesses. Quantitative metabolomics analysis and metabolic modeling applied in computational fluid dynamics (CFD)-assisted scale-down simulators that mimic industrial heterogeneity such as fluctuations in nutrients, dissolved gases, and other stresses can procure informative clues for coping with issues during bioprocessing scale-up. In previous studies, only limited insights into the hydrodynamic conditions inside the industrial-scale bioreactor have been obtained, which makes case-by-case scale-up far from straightforward. Tracking the flow paths of cells circulating in large-scale bioreactors is a highly valuable tool for evaluating cellular performance in production tanks. The “lifelines” or “trajectories” of cells in industrial-scale bioreactors can be captured using Euler-Lagrange CFD simulation. This novel methodology can be further coupled with metabolic (structured) models to provide not only a statistical analysis of cell lifelines triggered by the environmental fluctuations but also a global assessment of the metabolic response to heterogeneity inside an industrial bioreactor. For the future, the industrial design should be dependent on the computational framework, and this integration work will allow bioprocess scale-up to the industrial scale with an end in mind.

@en

In Penicillium chrysogenum, it has been observed that turnover of storage carbohydrates (trehalose, mannitol, arabitol, erythritol and glycogen) resulting in an extra ATP expenditure might partly account for the reduced penicillin productivity under dynamic cultivation conditions. In this work, Penicillium chrysogenum mutants with altered trehalose metabolism were constructed using the Agrobacterium-mediated transformation method. It was observed that impaired trehalose biosynthesis did not result in growth arrest and change of glucose sensitivity to high glucose levels, but negatively influenced the sporulation. Compared with the original strain, in glucose-limited chemostat cultures, the biomass yield on glucose and energy efficiency were slightly enhanced; however, the penicillin productivity was significantly lowered in the trehalose mutant strains. Comparison with a high-yielding P. chrysogenum strain revealed that the original and mutant strains had a lower glucose uptake capacity but higher intracellular levels of free amino acids. Flux estimates through the central carbon metabolism showed distinctive difference in the upper part of the glycolysis and in the pentose phosphate pathway but comparable flux through the TCA cycle. Combining, the striking phenotypic effects observed in the trehalose mutants of P. chrysogenum indicated that trehalose metabolism plays an important role in metabolic regulation and is central to maintaining higher penicillin productivity under glucose-limited chemostat cultures.

@en

During glucose-limited growth, a substantial input of adenosine triphosphate (ATP) is required for the production of β-lactams by the filamentous fungus Penicillium chrysogenum. Formate dehydrogenase has been confirmed in P. chrysogenum for formate oxidation allowing an extra supply of ATP, and coassimilation of glucose and formate has the potential to increase penicillin production and biomass yield. In this study, the steady-state metabolite levels and fluxes in response to cofeeding of formate as an auxiliary substrate in glucose-limited chemostat cultures at the dilution rates (D) of both 0.03 h⁻¹ and 0.05 h⁻¹ are determined to evaluate the quantitative impact on the physiology of a high-yielding P. chrysogenum strain. It is observed that an equimolar addition of formate is conducive to an increase in both biomass yield and penicillin production at D = 0.03 h⁻¹, while this is not the case at D = 0.05 h⁻¹. In addition, a higher cytosolic redox status (NADH/NAD⁺), a higher intracellular glucose level, and lower penicillin productivity are only observed upon formate addition at D = 0.05 h⁻¹, which are virtually absent at D = 0.03 h⁻¹. In conclusion, the results demonstrate that the effect of formate as an auxiliary substrate on penicillin productivity in the glucose-limited chemostat cultivations of P. chrysogenum is not only dependent on the formate/glucose ratio as published before but also on the specific growth rate. The results also imply that the overall process productivity and quality regarding the use of formate should be further explored in an actual industrial-scale scenario.

@en

Targeted, quantitative metabolomics can, in principle, provide precise information on intracellular metabolite levels, which can be applied to accurate modeling of intracellular processes required in systems biology and metabolic engineering. However, quantitative metabolite profiling is often hampered by biased mass spectrometry-based analyses caused by matrix effects, the degradation of metabolites and metabolite leakage during sample preparation, and unexpected variation in instrument responses. Isotope Dilution Mass Spectrometry (IDMS) has been proven as the most accurate method for high-throughput detection of intracellular metabolite concentrations, and the key has been the acquisition of the corresponding fully uniformly (U) - ¹³ C-labeled metabolites to be measured. Here, we have prepared U- ¹³ C-labeled cell extracts by cultivating P. chrysogenum in a fed-batch fermentation with fully U- ¹³ C-labeled substrates. Towards this goal, a dynamic fed-batch model describing P. chrysogenum growth and penicillin production was used to simulate the fermentation process and design the fed-batch fermentation media. Further, a case study with extensive intracellular metabolomics data from glucose-limited cultivation of Penicillium chrysogenum under both single and repetitive glucose pulses was illustrated by using the IDMS methods with the prepared U- ¹³ C-labeled cell extracts as internal standards. In conclusion, the IDMS method can be incorporated into well-established fast sampling and quenching protocols to obtain dynamic quantitative in vivo metabolome data at the timescales of (tens of) seconds and elucidate the underlying regulatory architecture. The case study revealed gross differences between single and repeated pulses, which suggests that single pulse studies have limited value for understanding of metabolic responses in large-scale bioreactors. Instead, intermittent feeding should be favored.

@en

In a 54 m³ large-scale penicillin fermentor, the cells experience substrate gradient cycles at the timescales of global mixing time about 20–40 s. Here, we used an intermittent feeding regime (IFR) and a two-compartment reactor (TCR) to mimic these substrate gradients at laboratory-scale continuous cultures. The IFR was applied to simulate substrate dynamics experienced by the cells at full scale at timescales of tens of seconds to minutes (30 s, 3 min and 6 min), while the TCR was designed to simulate substrate gradients at an applied mean residence time ((Formula presented.)) of 6 min. A biological systems analysis of the response of an industrial high-yielding P. chrysogenum strain has been performed in these continuous cultures. Compared to an undisturbed continuous feeding regime in a single reactor, the penicillin productivity (q_PenG) was reduced in all scale-down simulators. The dynamic metabolomics data indicated that in the IFRs, the cells accumulated high levels of the central metabolites during the feast phase to actively cope with external substrate deprivation during the famine phase. In contrast, in the TCR system, the storage pool (e.g. mannitol and arabitol) constituted a large contribution of carbon supply in the non-feed compartment. Further, transcript analysis revealed that all scale-down simulators gave different expression levels of the glucose/hexose transporter genes and the penicillin gene clusters. The results showed that q_PenG did not correlate well with exposure to the substrate regimes (excess, limitation and starvation), but there was a clear inverse relation between q_PenG and the intracellular glucose level.

@en

In the present work, by performing chemostat experiments at 400 and 600 RPM, two typical power inputs representative of industrial penicillin fermentation (P/V, 1.00 kW/m³ in more remote zones and 3.83 kW/m³ in the vicinity of the impellers, respectively) were scaled-down to bench-scale bioreactors. It was found that at 400 RPM applied in prolonged glucose-limited chemostat cultures, the previously reported degeneration of penicillin production using an industrial Penicillium chrysogenum strain was virtually absent. To investigate this, the cellular response was studied at flux (stoichiometry), residual glucose, intracellular metabolite and transcript levels. At 600 RPM, 20% more cell lysis was observed and the increased degeneration of penicillin production was accompanied by a 22% larger ATP gap and an unexpected 20-fold decrease in the residual glucose concentration (C_s,out). At the same time, the biomass specific glucose consumption rate (q_s) did not change but the intracellular glucose concentration was about sixfold higher, which indicates a change to a higher affinity glucose transporter at 600 RPM. In addition, power input differences cause differences in the diffusion rates of glucose and the calculated Batchelor diffusion length scale suggests the presence of a glucose diffusion layer at the glucose transporting parts of the hyphae, which was further substantiated by a simple proposed glucose diffusion-uptake model. By analysis of calculated mass action ratios (MARs) and energy consumption, it indicated that at 600 RPM glucose sensing and signal transduction in response to the low C_s,out appear to trigger a gluconeogenic type of metabolic flux rearrangement, a futile cycle through the pentose phosphate pathway (PPP) and a declining redox state of the cytosol. In support of the change in glucose transport and degeneration of penicillin production at 600 RPM, the transcript levels of the putative high-affinity glucose/hexose transporter genes Pc12g02880 and Pc06g01340 increased 3.5- and 3.3-fold, respectively, and those of the pcbC gene encoding isopenicillin N-synthetase (IPNS) were more than twofold lower in the time range of 100–200 hr of the chemostat cultures. Summarizing, changes at power input have unexpected effects on degeneration and glucose transport, and result in significant metabolic rearrangements. These findings are relevant for the industrial production of penicillin, and other fermentations with filamentous microorganisms.

@en

Oxygen limitation is regarded as a useful strategy to improve enzyme production by mycelial fungus like Aspergillus niger. However, the intracellular metabolic response of A. niger to oxygen limitation is still obscure. To address this, the metabolism of A. niger was studied using multi-omics integrated analysis based on the latest GEMs (genome-scale metabolic model), including metabolomics, fluxomics and transcriptomics. Upon sharp reduction of the oxygen supply, A. niger metabolism shifted to higher redox level status, as well as lower energy supply, down-regulation of genes for fatty acid synthesis and a rapid decrease of the specific growth rate. The gene expression of the glyoxylate bypass was activated, which was consistent with flux analysis using the A. niger GEMs iHL1210. The increasing flux of the glyoxylate bypass was assumed to reduce the NADH formation from TCA cycle and benefit maintenance of the cellular redox balance under hypoxic conditions. In addition, the relative fluxes of the EMP pathway were increased, which possibly relieved the energy demand for cell metabolism. The above multi-omics integrative analysis provided new insights on metabolic regulatory mechanisms of A. niger associated with enzyme production under oxygen-limited condition, which will benefit systematic design and optimization of the A. niger microbial cell factory.

@en

Background: Aspergillus niger is widely used for enzyme production and achievement of high enzyme production depends on the comprehensive understanding of cell's metabolic regulation mechanisms. Results: In this paper, we investigate the metabolic differences and regulation mechanisms between a high glucoamylase-producing strain A. niger DS03043 and its wild-type parent strain A. niger CBS513.88 via an integrated isotope-assisted metabolomics and ¹³C metabolic flux analysis approach. We found that A. niger DS03043 had higher cell growth, glucose uptake, and glucoamylase production rates but lower oxalic acid and citric acid secretion rates. In response to above phenotype changes, A. niger DS03043 was characterized by an increased carbon flux directed to the oxidative pentose phosphate pathway in contrast to reduced flux through TCA cycle, which were confirmed by consistent changes in pool sizes of metabolites. A higher ratio of ATP over AMP in the high producing strain might contribute to the increase in the PP pathway flux as glucosephosphate isomerase was inhibited at higher ATP concentrations. A. niger CBS513.88, however, was in a higher redox state due to the imbalance of NADH regeneration and consumption, resulting in the secretion of oxalic acid and citric acid, as well as the accumulation of intracellular OAA and PEP, which may in turn result in the decrease in the glucose uptake rate. Conclusions: The application of integrated metabolomics and ¹³C metabolic flux analysis highlights the regulation mechanisms of energy and redox metabolism on flux redistribution in A. niger. Graphical abstract An integrated isotope-assisted metabolomics and ¹³C metabolic flux analysis was was firstly systematically performed in A. niger. In response to enzyme production, the metabolic flux in A. niger DS03043 (high-producing) was redistributed, characterized by an increased carbon flux directed to the oxidative pentose phosphate pathway as well as an increased pool size of pentose. The consistency in ¹³C metabolic flux analysis and metabolites quantification indicated that an imbalance of NADH formation and consumption led to the accumulation and secretion of organic acids in A. niger CBS513.88 (wild-type)

@en