Ceramic nanofiltration is a potential one-step treatment for industrial waste streams. It can remove colloidal particles, oil droplets and some organic molecules. The drawback of the technology is that backwash cannot be applied to remove the accumulated cake layer from the membrane surface. At the moment only chemical cleaning with aggressive oxidizing agents like chlorine are effective to restore the permeability of the membranes after fouling. However, calcium carbonate (CaCO3) precoating has shown potential benefits in preliminary research, but have only been executed at laboratory scale, under a constant pressure and with a limited number of experimental cycles. In the presented work, the CaCO3 precoat/acid cleaning method was comprehensively studied under varying operational conditions. Dead-end filtration of a CaCO3-dispersion was used to precoat the membrane surface. Three different acids were tested to partly dissolve the precoat and remove the cake layer from the membrane surface. It was found that citric acid performed the best to recover the permeability of the membrane, probably due to the chelating properties, capturing the calcium ions, with a good removal of the cake layer during forward flush as a result. The size of precoat particles influenced the efficacy of permeability recovery. The smaller the deposited precoating particles on the membrane surface were, the better the cleaning effect was. It is expected that, when filtering real sewage water, these membranes can operate with one precoat during about 25 days with five consecutive citric acid cleaning cycles before a chlorine-based chemical treatment should thoroughly clean the membrane module.@en

Marine microorganisms have an inherent advantage in the treatment of saline wastewater due to their halophilic properties. Ammonium assimilation is the most important and common nitrogen conversion pathway in the ocean, which means that it may be a suitable nitrogen removal strategy under high salinity conditions. However, the targeted construction of engineering microbiomes with ammonium assimilation function for nitrogen recovery has not been realized. Here, we constructed four halophilic ammonium assimilation microbiomes from marine microbial community under varying chemical oxygen demand (COD) to nitrogen (COD/N) ratios. The regulation of COD/N ratio on microbial self-assembly was explored at the phenotypic, genetic, and microbial levels. The results of nitrogen balance tests, functional genes abundance and microbial community structure confirmed that the microbiomes regulated by different COD/N ratios all performed obligate ammonium assimilation functions. >93% of ammonium, 90% of TN, 98% of COD, and 82% of phosphorus were simultaneously removed by microbial assimilation under the COD/N ratio of 20. COD/N ratios significantly affected the self-assembly of microbiomes by selectively enriching heterotrophic microorganisms with different preference for organic carbon load. Additionally, the increase of COD/N ratio intensified the competition among species within the microbiome (the proportion of negative connections of microbial network increased from 5.0% to 24.4%), which may enhance the stability of community structure. Taken together, these findings can provide theoretical guidance for the construction and optimization of engineering microbiomes for synergistic nitrogen removal and recovery.

@en

This study aims at applying and verifying the MFI-UF method to predict particulate fouling in RO plants. Two full-scale RO plants treating surface water, with average capacity of 800–2000 m³/h, were studied. Firstly, the MFI-UF of RO feed and concentrate was measured using 5–100 kDa membranes at same flux applied in the RO plants (20–26 L/m².h). Subsequently, the particle disposition factor (Ω) was calculated to simulate particle deposition in RO cross-flow filtration. Finally, particulate fouling rates were predicted based on MFI-UF and Ω, and compared with the actual fouling rates in the plants. For plant A, the results showed that the fouling rates predicted using MFI-UF measured with 100 kDa membrane have the best agreement with the actual fouling (with 3–11 % deviation). For plant B, the fouling rates predicted based on both 10 and 100 kDa membranes agree well with the actual fouling (with 2 % and 15 % deviation, respectively). However, the fouling predicted based on 5 kDa membrane is considerably overestimated for both plants, which is attributed to the effect of the low surface porosity of 5 kDa membrane. More widespread applications of MFI-UF in full-scale RO plants are required to demonstrate the most suitable MFI-UF membranes for fouling prediction.

@en

The contradiction between theoretical metabolism of ammonium assimilation and experiential understanding of conventional biosystems makes the rational optimization of the ammonium-assimilating microbiome through carbon to nitrogen (C/N) ratios perplexing. The effect of different C/N ratios on ammonium-assimilating biosystems was investigated in saline wastewater treatment. C/N ratios significantly hindered the nutrient removal efficiency, but ammonium-assimilating biosystems maintained functional stability in nitrogen conversions and microbial communities. With sufficient biomass, higher than 86% ammonium and 73% phosphorus were removed when C/N ratios were higher than 25. Ammonium assimilation dominated the nitrogen metabolism in all biosystems even under relatively low C/N ratios, evidenced by the extremely low abundances of nitrification functional genes. Different C/N ratios did not significantly change the bacterial community structure of ammonium-assimilating biosystems. It is anticipated that the ammonium-assimilating biosystem with advantages of clear metabolic pathway and easy optimization can be applied to nutrient removal and recovery in saline environments.

@en

Wastewater with high salinity is one of the major challenges for conventional wastewater treatment. Although nitrogen management is vital for wastewater treatment, efficient strategies for nitrogen recovery and removal from saline wastewater remain challenging. Here we propose microbial ammonium assimilation to achieve efficient nitrogen removal and recovery into biomass from saline wastewater without gaseous nitrogen release opposite to the conventional wastewater treatment,. We find one marine bacterium Psychrobacter aquimaris A4N01 with the ability to form sedimentary granular biofilms that can be engineered to construct an efficient ammonium-assimilating microbiome followed the bottom-up design. We demonstrate that the microbiome removes ammonium through assimilation without reactive nitrogen intermediates and gaseous nitrogen emission, according to the functional gene abundance and nitrogen balance. More than 80% of ammonium, total nitrogen and total phosphorus are removed and recovered into biomass, with more than 98% of COD removed from saline wastewater. As one prototypic microbe to form ammonium-assimilating biofilms, Psychrobacter aquimaris A4N01 plays key role in nutrient metabolism and microbiome construction. We stress that ammonium assimilation with a clear and short pathway is a promising method in future saline wastewater treatment and sustainable nitrogen management.@en