The global market for the wastewater treatment industry has been compelled to devise new concepts due to several factors. Currently, approximately 80% of untreated wastewater is discharged worldwide. The conventional technology for municipal solid waste treatment, which has been in use for over a century, is only partially effective in terms of effluent quality and energy balance. The highly flammable CH4 gas emitted from municipal solid waste landfills impacts the chemical composition of the atmosphere, potentially affecting the Earth. Thus, new concepts for wastewater treatment should address multiple social challenges related to energy and sanitation technologies. A well–implemented wastewater treatment system not only contributes to mankind wellbeing, which results in more effective population planning, but also ensures the optimal utilization of environmental resources.....@en

The low cost of electricity in some areas facilitates the adoption of high-temperature electrolysis plants for the large-scale storage of electricity. Supercritical water gasification (SCWG) is a promising method of syngas production from wet biomass. Additionally, it is a potential source of steam for electrochemical plants. However, the commercialisation of standalone SCWG systems is hindered by low efficiency and high operating cost. Accordingly, we propose the integration of SCWG with a reversible solid oxide cell (rSOC) to realise simultaneous syngas or power generation and wet biomass conversion. This technique would make the process feasible in terms of energy, allowing engineers to use SCWG to combine power generation with fuel production. The wet syngas from the SCWG is fed to the rSOC powered by excess renewable electricity in electrolysis mode, where steam is reduced to H₂ to produce dry syngas with a higher calorific value. The energy efficiency of the proposed system is 91% in electrolysis mode and 47% in fuel cell mode. The electrolysis increases the syngas yield by a factor of thirteen and the use of total syngas generates twelve times more power in fuel cell mode compared to the use of only fresh syngas from SCWG.

@en

Nowadays, there is worldwide interest in diversifying energy supply. In this regard, biomass is the best possible renewable organic substitute for fossil fuels. In particular, the energy content of very wet biomass, recovered with appropriate technology, could potentially be used for power generation. In addition to power generation, this technology would represent a sanitary option to improve the quality of public health and the environment. Supercritical water gasification (SCWG) is a technology applied for the conversion of wet biomass into gas. It uses the specific physical properties of water at supercritical conditions to decompose the organic matter. However, near 100% conversion, close to thermodynamic equilibrium, of real biomass into gas is not yet demonstrated. The conversion is higher at dry biomass concentrations below 10 wt.%, but at these conditions, the system is not energetically sustainable. The conversion depends on the SCWG operating conditions and the properties of the catalyst. Because of present-day technical limitations, the conversion efficiency in SCWG is low when fed with real biomass. The net electrical efficiency of a combined system SCWG—solid oxide fuel cell (SOFC), fed with fecal sludge at 15 wt.% dry biomass, reaches between 50 and 70% (thermodynamically calculated values), whereas utilizing an SCWG designed with present-day engineering gives 29–40%. The SOFC fuel utilization influences the system efficiency significantly, as the processed heat available for the heat integration depends on fuel utilization. The extreme operating conditions of an SCWG-based system cause technical limitations toward reaching complete conversion during gasification. An efficient and stable catalyst is not yet available at competitive costs for low-temperature SCWG of real biomass. Intensive research in different gasification-SOFC system configurations that include the integration of complementary processes, such as the electrochemical oxidation of higher hydrocarbons or the electrochemical reduction of CO₂ and H₂O, will increase the potential of the gasification–SOFC system for commercialization in medium scale in the future and become a technology that provides economic, environmental, and health benefits.

@en

Sustainable development goals for 2030 aim at the extensive reduction of the global sanitation breach; this might be achieved by renewed sanitation technologies and while providing sanitation recover valuable products such as energy. Consequently, this work presents a gasification–solid oxide fuel cell (SOFC) power plant that was configured for high-efficiency energy recovery from faecal sludge. The main limitations of faecal sludge gasification are the production of impurities, such as tar, and the high energy requirements for both the endothermic gasification process and removing the high moisture content in the feedstock. However, results from this work indicate that a superheated steam dryer combined with an indirectly heated multistage gasifier and a gas-cleaning unit can overcome the mentioned limitations. The external heat for the gasifier is supplied by the process heat available and a microwave plasma torch, and there is sufficient heat to drive a micro steam turbine. Thermodynamic calculations indicated that the plant could reach a net electrical efficiency of the order of 65%. As a result, a gasification–SOFC power plant is more suitable for energy recovery than any other process such as biochar production by pyrolysis; hence, it might become a technology that is financially feasible and can be used globally for sanitation purposes.

@en

This paper describes the steps involved in the design, construction, and testing of a gasifier-specific solid oxide fuel cell (SOFC) system. The design choices are based on reported thermodynamic simulation results for the entire gasifier- gas cleanup-SOFC system. The constructed SOFC system is tested and the measured parameters are compared with those given by a system simulation. Furthermore, a detailed exergy analysis is performed to determine the components responsible for poor efficiency. It is concluded that the SOFC system demonstrates reasonable agreement with the simulated results. Furthermore, based on the exergy results, the components causing major irreversible performance losses are identified.@en

Using catalytic supercritical water gasification (CSCWG) in generating energy from wet biomass is efficient and environmentally friendly. However, one of the main challenges in using CSCWG is the low syngas yield and low heating value. Syngas for power and for synthetic fuel production requires high-purity and a high heating value. In this work, a novel system is proposed which increases the CSCWG syngas heating value and yield and produce electricity using a reversible solid oxide cell (ReSOC). The plant can be used for syngas production, working in electrolyser mode powered by excess renewable electrical energy. Thermodynamic calculations indicate that the energy efficiency of the CSCWG-SOEC is in the order of 72%, in this mode the syngas yield increases around five times and is rich in hydrogen and methane, its composition allows operation within the carbon-free region of the C-H-O diagram.@en

A summary of research activities and on-going multiple projects at Delft University of Technology aimed at the development of Solid Oxide Fuel Cells (SOFCs) integrated waste to energy systems are presented in this paper. A wide range of studies ranging from pattern cell impedance analysis to integrated system development is also presented. Cleaning the gas to match constraints of SOFCs requires complex approaches. A brief discussion on the achievable system efficiencies with SOFC integrated waste to energy systems is presented and novel concepts such as gasifier-Reversible SOFC integrated power production cum energy storage systems are discussed. Additionally, an overview of a wide range of national, European and international projects that helped or currently helping us to carry out the above mentioned research activities are presented.@en