Summary: The objective of this study was to evaluate a non-resorbable implant for the focal repair of osteochondral defects. Enhanced adherence of repair cartilage overgrowing the implants was the secondary goal and was tested by introducing porosities on the articular surface of the implant. This study evaluated four versions of the construct composed of a polycarbonate-urethane-urea biomaterial (elastomer) and a bone anchor. In order to induce porosities on the surface of the implant, either vertical holes were punched into it, or the chondral component was 3D-printed onto the implant. Fabrication, biomechanical characterization and cell infiltration of the implant were evaluated in-vitro. Subsequently the implants were tested in an in-vivo study in four Shetland ponies for 5 weeks. Enhanced porosity was successfully obtained for all implants. The 3D-printing of the elastomeric material produced pore diameters of 775μm and 690μm whilst the micro-punched pores had a diameter of 319μm. The elastic modulus of the elastomer decreased with the introduction of porosity but stayed above values of native cartilage in all versions of the implant. Clinically the implant was well tolerated. The over-growing repair tissue was mostly flush with surrounding cartilage and attached to the elastomer through ingrowth of the tissue into the pores. Overall the tested implants all showed good mechanical performance in vitro and subjectively also in vivo. The repair cartilage was solidly attached to the porous surface of the implant. The printing approach potentially enables fine-tuning of the biomechanical properties of the implant depending on the specific requirements for a given location.

@en

OBJECTIVE: Folate receptor beta (FR-β) has been used as a clinical marker and target in multiple inflammatory diseases, including osteoarthritis (OA) and rheumatoid arthritis (RA). However, the conditions under which FR-β+ macrophages arise remain unclear and could be affected by corticosteroids. Therefore, we studied FR-β expression in vitro in macrophage subtypes and determined their response to triamcinolone acetonide (TA), a clinically often-used corticosteroid. DESIGN: Human monocyte-derived macrophages were differentiated to the known M0, M1, or M2 macrophage phenotypes. The phenotype and FR-β expression and plasticity of the macrophage subtypes were determined using flow cytometry, reverse transcription-quantitative polymerase chain reaction (RT-qPCR), and enzyme-linked immunosorbent assay (ELISA). RESULTS: FR-β expression was low in granulocyte-macrophage colony-stimulating factor (GM-CSF)-generated (M1-like) macrophages and high in macrophage colony-stimulating factor (M-CSF)-generated (M0 and M2-like) macrophages. FR-β expression remained high once the M0 or M2 macrophages were stimulated with pro-inflammatory stimuli (interferon-γ plus lipopolysaccharide) to induce M1-like macrophages. On the contrary, anti-inflammatory TA treatment skewed GM-CSF macrophage differentiation toward an M2 and FR-β+ phenotype. CONCLUSIONS: As corticosteroids skewed monocytes toward an FR-β-expressing, anti-inflammatory phenotype, even in an M1 priming GM-CSF environment, FR-β has potential as a biomarker to monitor success of treatment with corticosteroids. Without corticosteroid treatment, M-CSF alone induces high FR-β expression which remains high under pro-inflammatory conditions. This explains why pro-inflammatory FR-β+ macrophages (exposed to M-CSF) are observed in arthritis patients and correlate with disease severity.

@en

Since Galileo's days the effect of size on the anatomical characteristics of the structural elements of the body has been a subject of interest. However, the effects of scaling at tissue level have received little interest and virtually no data exist on the subject with respect to the osteochondral unit in the joint, despite this being one of the most lesion-prone and clinically relevant parts of the musculoskeletal system. Imaging techniques, including Fourier transform infrared imaging, polarized light microscopy and micro computed tomography, were combined to study the response to increasing body mass of the osteochondral unit. We analyzed the effect of scaling on structural characteristics of articular cartilage, subchondral plate and the supporting trabecular bone, across a wide range of mammals at microscopic level. We demonstrated that, while total cartilage thickness scales to body mass in a negative allometric fashion, thickness of different cartilage layers did not. Cartilage tissue layers were found to adapt to increasing loads principally in the deep zone with the superficial layers becoming relatively thinner. Subchondral plate thickness was found to have no correlation to body mass, nor did bone volume fraction. The underlying trabecular bone was found to have thicker trabeculae (r = 0.75, p < 0.001), as expected since this structure carries most loads and plays a role in force mitigation. The results of this study suggest that the osteochondral tissue structure has remained remarkably preserved across mammalian species during evolution, and that in particular, the trabecular bone carries the adaptation to the increasing body mass.

@en

The aim of this study was to develop a formulation with a sustained intra-articular release of the anti-inflammatory drug tacrolimus. Drug release kinetics from the prepared tacrolimus loaded monodisperse biodegradable microspheres based on poly(d-l-lactide-PEG)-b-poly(l-lactide) multiblock copolymers were tunable by changing polymer composition, particularly hydrophobic-hydrophilic block ratio. The monospheres were 30 μm and released the drug, depending on the formulation, in 7 to >42 days. The formulation exhibiting sustained release for 1 month was selected for further in vivo evaluation. Rat knees were injected with three different doses of tacrolimus (10 wt %) loaded monospheres (2.5, 5.0, and 10 mg), contralateral control knees with saline. Micro-CT and histology showed no negative changes on cartilage, indicating good biocompatibility. Minor osteophyte formation was seen in a dose dependent fashion, suggesting local drug release and therapeutic action thereof. To investigate in vivo drug release, tacrolimus monospheres were injected into horse joints, after which multiple blood and synovial fluid samples were taken. Sustained intra-articular release was seen during the entire four-week follow-up, with negligible systemic drug concentrations (<1 ng/mL), confirming the feasibility of local intra-articular drug delivery without provoking systemic effects. Intra-articular injection of unloaded monospheres led to a transient inflammatory reaction, measured by total synovial leucocyte count (72 h). This reaction was significantly lower in joints injected with tacrolimus loaded monospheres, showing not only the successful local tacrolimus delivery but also local anti-inflammatory action. This local anti-inflammatory potential without systemic side-effects can be beneficial in the treatment of inflammatory joint diseases, among which is osteoarthritis.

@en

Cross-talk of subchondral bone and articular cartilage could be an important aspect in the etiology of osteoarthritis. Previous research has provided some evidence of transport of small molecules (~370 Da) through the calcified cartilage and subchondral bone plate in murine osteoarthritis models. The current study, for the first time, uses a neutral diffusing computed tomography (CT) contrast agent (iodixanol, ~1550 Da) to study the permeability of the osteochondral interface in equine and human samples. Sequential CT monitoring of diffusion after injecting a finite amount of contrast agent solution onto the cartilage surface using a micro-CT showed penetration of the contrast molecules across the cartilage-bone interface. Moreover, diffusion through the cartilage-bone interface was affected by thickness and porosity of the subchondral bone as well as the cartilage thickness in both human and equine samples. Our results revealed that porosity of the subchondral plate contributed more strongly to the diffusion across osteochondral interface compared to other morphological parameters in healthy equine samples. However, thickness of the subchondral plate contributed more strongly to the diffusion in slightly osteoarthritic human samples.@en