This study investigated the performance of direct hollow fiber nanofiltration (dNF40) membranes from NX Filtration BV on a pilot scale for the treatment of pre-treated IJsselmeer water from Waterwinstation Prinses Juliana (WPJ) in Andijk, as well as the direct treatment of raw IJsselmeer water. The objective was to evaluate the long-term fouling potential and the retention of ions and natural organic matter (NOM) using both WPJ pre-treated IJsselmeer water and raw IJsselmeer water. Additionally, the rejection of organic micropollutants (OMPs) under artificially elevated conditions, referred to as ‘spiked solution’, using WPJ pre-treated IJsselmeer water was investigated. Limited to no fouling was observed on the dNF40 membrane during stable operation when treating both WPJ pre-treated IJsselmeer water and raw IJsselmeer water, even under changing process conditions. NOM removal consistently exceeded 90% regardless of process conditions or water type. The retention of per- and polyfluoroalkyl substances (PFAS) was above 80%, with even higher retention observed for higher molecular weight values. Low molecular weight pharmaceuticals, all below the molecular weight cut-off (MWCO) of the dNF40 membrane (400 Da), exhibited approximately 30% retention. The dNF40 membrane showed better retention of negatively charged pharmaceuticals in the spiked solution compared to positively charged and neutral pharmaceuticals. A total cost of ownership (TCO) analysis unveiled that operational expenditures (OPEX) were three times higher than capital expenditures (CAPEX) for a 5-stage full-scale dNF40 system. Among the components, membrane replacement costs constituted the majority of OPEX (68%), followed by energy costs (31%) and chemical costs (<1%). Overall, the study showcased the suitability of the dNF40 membranes for treating IJsselmeer water, achieving effective removal of NOM and PFAS.

Source-separated gray water reclamation using nanofiltration as an advanced post-treatment option has received substantial interest in meeting the growing water demand. During reclamation, membrane integrity is crucial to ensure the water’s safety. This study evaluated several chemical and novel microbial indicators as indirect membrane integrity-monitoring methods for hollow fiber nanofiltration membranes in reclamation schemes. Under normal conditions, high retention of divalent ions and organic matter and near-complete removal of Escherichia coli (E. coli) were observed. Limited removal of the antibiotic gene (ARG) tetO was observed due to low feed concentrations and a higher detection limit (LOD). While 16S rRNA and ARG sul1 were not limited by their LODs, lower removals were observed, most likely due to free-floating DNA passing through the membranes. A broken fiber in a pilot-scale module reduced organic matter and microorganism removal substantially, while flux and ion rejection remained similar. Predictions made using the observed results and a previously proposed model allowed for the evaluation of the selected methods in upscaled reclamation systems. Based on these results, it was concluded that microorganisms could be employed as indicators in indirect membrane integrity-monitoring methods in large-scale reclamation schemes, while UV_254nm absorbance (used in organic matter determination) could be a viable solution in pilot-scale systems.