Non-oxidative dehydroaromatization of methane (MDA) is a promising catalytic process for direct valorization of natural gas to liquid hydrocarbons. The application of this reaction in practical technology is hindered by a lack of understanding about the mechanism and nature of the active sites in benchmark zeolite-based Mo/ZSM-5 catalysts, which precludes the solution of problems such as rapid catalyst deactivation. By applying spectroscopy and microscopy, it is shown that the active centers in Mo/ZSM-5 are partially reduced single-atom Mo sites stabilized by the zeolite framework. By combining a pulse reaction technique with isotope labeling of methane, MDA is shown to be governed by a hydrocarbon pool mechanism in which benzene is derived from secondary reactions of confined polyaromatic carbon species with the initial products of methane activation.

Liu et al. recently reported their results on coconversion of methane and methanol at 973 K over a typical methane dehydroaromatization (MDA) catalysts, Mo/HZSM-5.1 In this work, the authors claimed that adding a small amount of methanol to a methane feed led to more than two times higher methane conversion, substantially higher xylene and toluene selectivities (i.e., combined ca. 80%, nearly an order of magnitude increase as compared to experiments without methanol), and improved catalyst stability to such an extent that no deactivation was observed during 60 h on stream. If reproducible, this result would be a significant achievement, because formation of coke in the MDA reaction has been considered inevitable hitherto. To support their experimental data, Liu et al. carried out a thermodynamic analysis, whose results were in good agreement with their experimental findings.